BSE transmission safeguards
Several new public health measures will be implemented by the Food and Drug Administration (FDA), to strengthen significantly the multiple existing firewalls that protect Americans from exposure to the agent thought to cause bovine spongiform encephalopathy (BSE, also known as mad cow disease) and that help prevent the spread of BSE in U.S. cattle.
The existing multiple firewalls, developed by both the U.S. Department of Agriculture (USDA) and HHS, have been extremely effective in protecting the American consumer from exposure to BSE. The first firewall is based on import controls started in 1989. A second firewall is surveillance of the U.S. cattle population for the presence of BSE, a USDA firewall that led to the finding of the BSE cow in December. The third firewall is FDA's 1997 animal feed ban, which is the critical safeguard to help prevent the spread of BSE through cattle herds by prohibiting the feeding of most mammalian protein to ruminant animals, including cattle. The fourth firewall, recently announced by USDA, makes sure that no bovine tissues known to be at high risk for carrying the agent of BSE enter the human food supply regulated by USDA. The fifth firewall is effective response planning to contain the potential for any damage from a BSE positive animal, if one is discovered. This contingency response plan, which had been developed over the past several years, was initiated immediately upon the discovery of a BSE positive cow in Washington State December 23.
The new safeguards are science-based and further bolster these already effective safeguards.
Specifically, HHS intends to ban from human food (including dietary supplements), and cosmetics a wide range of bovine-derived material so that the same safeguards that protect Americans from exposure to the agent of BSE through meat products regulated by USDA also apply to food products that FDA regulates.
FDA will also prohibit certain currently allowed feeding and manufacturing practices involving feed for cattle and other ruminant animals. These additional measures will further strengthen FDA's 1997 "animal feed" rule.
To implement these new protections, FDA will publish two interim final rules that will take effect immediately upon publication, although there will be an opportunity for public comment after publication.
The first interim final rule will ban the following materials from FDA-regulated human food, dietary supplements, and cosmetics:
any material from "downer" cattle (i.e., cattle that cannot walk);
- any material from "dead" cattle (i.e., cattle that die on the farm before reaching the slaughter plant);
- Specified Risk Materials (SRMs) that are known to harbor the highest concentrations of the infectious agent for BSE, such as the brain, skull, eyes, and spinal cord of cattle 30 months or older, and a portion of the small intestine and tonsils from all cattle, regardless of their age or health; and
- the product known as mechanically separated beef, a product that may contain SRMs; meat obtained by Advanced Meat Recovery (an automated system for cutting meat from bones) may be used since USDA regulations do not allow the presence of SRMs in this product.
The second interim final rule is designed to lower even further the risk that cattle will be purposefully or inadvertently fed prohibited protein. It was the feeding of such protein to cattle that was the route of disease transmission that led to the BSE epidemic in United Kingdom cattle in the 1980's and 1990's.
This interim final rule will implement four specific changes in FDA's present animal feed rule. The rule:
- Will eliminate the present exemption in the feed rule that allows mammalian blood and blood products to be fed to other ruminants as a protein source. Recent scientific evidence suggests that blood can carry some infectivity for BSE.
- Will also ban the use of "poultry litter" as a feed ingredient for ruminant animals. Poultry litter consists of bedding, spilled feed, feathers, and fecal matter that are collected from living quarters where poultry is raised. This material is then used in cattle feed in some areas of the country where cattle and large poultry raising operations are located near each other. Poultry feed may legally contain protein that is prohibited in ruminant feed, such as bovine meat and bone meal. The concern is that spillage of poultry feed in the chicken house occurs and that poultry feed (which may contain protein prohibited in ruminant feed) is then collected as part of the "poultry litter" and added to ruminant feed.
- Will ban the use of "plate waste" as a feed ingredient for ruminants. Plate waste consists of uneaten meat and other meat scraps that are currently collected from some large restaurant operations and rendered into meat and bone meal for animal feed. The use of "plate waste" confounds FDA's ability to analyze ruminant feeds for the presence of prohibited proteins, compromising the Agency's ability to fully enforce the animal feed rule.
- Will further minimize the possibility of cross-contamination of ruminant and non-ruminant animal feed by requiring equipment, facilities or production lines to be dedicated to non-ruminant animal feeds if they use protein that is prohibited in ruminant feed. Currently, some equipment, facilities and production lines process or handle prohibited and non-prohibited materials and make both ruminant and non-ruminant feed -- a practice which could lead to cross-contamination.
To accompany these new measures designed to provide a further layer of protection against BSE, FDA will in 2004 step up its inspections of feed mills and renderers. FDA will itself conduct 2,800 inspections and will make its resources go even further by continuing to work with state agencies to fund 3,100 contract inspections of feed mill and renderers and other firms that handle animal feed and feed ingredients. Through partnerships with states, FDA will also receive data on 700 additional inspections, for a total of 3,800 state contract and partnership inspections in 2004 alone, including annual inspections of 100 percent of all known renderers and feed mills that process products containing materials prohibited in ruminant feed.
The FDA also notes that in response to finding a BSE positive cow in Washington state December 23, it has inspected and traced products at 22 facilities related to that positive cow or products from the cow, including feed mills, farms, dairy farms, calf feeder lots, slaughter houses, meat processors, transfer stations, and shipping terminals. Moreover, FDA has conducted inspections at the rendering facilities that handled materials from the positive cow, and they were found to be fully in compliance with FDA's feed rule.
To further strengthen protections for Americans, FDA/HHS intends to work with Congress to consider proposals to assure that these important protective measures will be implemented as effectively as possible.
FDA is also continuing its efforts to assist in the development of better BSE science, to achieve the same or greater confidence in BSE protection at a lower cost. For example, to enhance the ability of the US public health system to detect prohibited materials in animal feed, FDA will continue to support the development and evaluation of diagnostic tests to identify prohibited materials. These tests would offer a quick and reliable method of testing animal feeds for prohibited materials and for testing other products for contamination with the agent thought to cause BSE.